Monday, November 14, 2011

How to remove ABS Accumulator on Acura Integra?

The details are as follows :---

Accumulator


REMOVAL & INSTALLATION



See Figure 1
Click image to see an enlarged view
Fig. Fig. 1: Accumulator and pressure switch assembly
The ABS accumulator is a pneumatic type which stores high pressure brake fluid which is fed from the pump assembly. As the ABS operates, the accumulator works in conjunction with the pump to supply extremely high pressure fluid to the modulator valve.
  1. Disconnect the negative battery cable.
  2. To remove the accumulator you must first remove the pump assembly, as outlined later in this section.
  3. Place the pump assembly in a vise and loosen the accumulator by turning it counter clockwise with an open-end wrench.
See Figure 2
Click image to see an enlarged view
Fig. Fig. 2: Removing the accumulator from the pump assembly
  1. The pressure in the accumulator must be released before disposing of it in the trash.
  2. To relieve the accumulator pressure, perform the following:
    1. Secure the accumulator in a vise.
See Figure 3
Click image to see an enlarged view
Fig. Fig. 3: Removing the relief plug to allow the pressure to escape
  1. Slowly turn the plug three to four turns.
  2. Allow five minutes for the pressure to escape.
  3. Completely remove the relief plug from the accumulator.
  1. Discard the accumulator.
  2. Install the accumulator assembly in the reverse order of the removal procedure.

---------------
------------
For more car related problem troubleshooting:---

This are the sections, you can go through and click the link to read its troubleshooting.

---------

Lexus: Anti-lock Brake System Actuator?


2001 Lexus IS 250 and IS 350.
Lexus: Actuator replacing for Anti-lock Brake System?
Click the link below:---



2001 Lexus ES 300 :---
How to replace ABS Actuator on 2001 Lexus?
Click the link below:---

Lexus: How to bleed ABS system?

Click the link below:--


What is ABS and how does it works on vehicles?


How to test ABS system in vehicle?


Lexus: Wheel Speed Sensors Removal?


How to manually bleed brake systems on Lexus?


How to remove brake pads on 2001 Lexus?


How to replace brake Caliper on 2001 Lexus ?


 

2001 Lexus: Brake Disc Rotor removal?


Brake Pads replacing on 2001 Lexus?


How to adjust parking Brake cable on 2001 Lexus?


How to adjust parking Brake shoes on 2001 Lexus?


Rear Brake Pads removal on 2001 Lexus?


Rear Brake Rotor replacing on 2001 Lexus?


Removing Rear Brake Caliper on 2001 Lexus?

http://howtobyme.blogspot.com/2011/10/removing-rear-brake-caliper-on-2001.html
-----------

The car will not start?

-----------------

Car will not crank?


-----------

Car has no spark?


-------------

How to troubleshoot car battery?

-----------------

How to test starter solenoid?

http://schematicsdiagram.blogspot.com/2011/06/how-to-test-starter-solenoid.html

--------------------

How to test cars starter?

http://schematicsdiagram.blogspot.com/2011/06/how-to-test-cars-starter.html

How to replace starter in car?



-----------

car will turn over but will not start?



-----------------

Car wont start?


----------


No comments:

Post a Comment