Friday, February 10, 2012

How to replace power steering pump on Toyota Land cruiser?

The procedure to complete this tough task is as follows:----

  1. Disconnect the MAF meter connector.
  2. For this check this two links mentioned below :------ 
  3. Disconnect the hoses.
  4. Remove the clamp.
  5. Remove the 3 bolts and air cleaner assembly with air cleaner hose connected.
  6. Loosen the drive belt tension by turning the drive belt tensioner counterclockwise, and remove the drive belt.
  7. Remove the 2 clips and disconnect the 2 vacuum hoses.
  8. Remove the clip and disconnect the return hose.
  9. Remove the union bolt and gasket, disconnect the pressure feed tube.
  10. Remove the 2 bolts, nut, stud bolt and power steering pump assembly.
To install:
  1. Install the power steering pump assembly with the stud bolt.
  2. Tighten the stud bolt to 22 Nm (16 ft. lbs.)
  3. Install the 2 bolts and nut and tighten them to 44 Nm (33 ft. lbs.)
  4. Install a new gasket and the union bolt on the pressure feed tube. 
    NOTE
    Make sure that the stopper of the pressure feed tube contacts the power steering pump body as shown in the illustration.



    Click image to see an enlarged view
    Fig. Pressure feed tube positioning
  5. Tighten the union bolt to 46.5 Nm (34 ft. lbs.)
  6. Connect the return hose with the clip.
  7. Connect the 2 vacuum hoses and install the 2 clips.
  8. Loosen the drive belt tension by turning the drive belt tensioner counterclockwise, and install the belt.
  9. Install the air cleaner assembly with air cleaner hose and the 3 bolts.
  10. Install the clamp.
  11. Connect the MAF meter connector.
  12. Fill with power steering fluid and bleed the system.

For bleeding the power steering pump  system,click the link below :----


This will help.
Thanks.

See below latest solved car problems :----

Mazda MPV cranks but will not start?

http://technoanswers.blogspot.com/2012/01/mazda-mpv-cranks-but-will-not-start.html

MAZDA MPV WILL CRANK BUT NOT TURN OVER TO START?

http://technoanswers.blogspot.com/2012/01/mazda-mpv-will-crank-but-not-turn-over.html

Freightliner fl112 fuse box diagram?

http://technoanswers.blogspot.com/2012/01/freightliner-fl112-fuse-box-diagram.html

Car will not turn the ignition to start?

http://technoanswers.blogspot.com/2012/01/car-will-not-turn-ignition-to-start.html

Car only starts when gas pedal is pressed?

http://technoanswers.blogspot.com/2012/01/car-only-starts-when-gas-pedal-is.html

Hyundai coupe f2 hazard fault?

http://schematicsdiagram.blogspot.com/2012/01/hyundai-coupe-f2-hazard-fault.html

Where is the bulb located in glove box?

http://repairhelpcenter.blogspot.com/2012/01/where-is-bulb-located-in-glove-box.html

Additional wiring harness needs to be installed in a brake controller for electric brakes on 2012 Toyota Highlander?

http://repairhelpcenter.blogspot.com/2012/01/additional-wiring-harness-needs-to-be.html

Fail smog test due to gas filter hose?

http://repairhelpcenter.blogspot.com/2012/01/fail-smog-test-due-to-gas-filter-hose.html

Clutch squeaking under hood?

http://repairhelpcenter.blogspot.com/2012/01/clutch-squeaking-under-hood.html

Engine stalls when gas is given?

http://technoanswers.blogspot.in/2012/01/engine-stalls-when-gas-is-given.html

1990 mazda 323 stalls and quit running?

http://technoanswers.blogspot.in/2012/02/1990-mazda-323-stalls-and-quit-running.html

Nissan car will not start?

http://technoanswers.blogspot.in/2012/02/nissan-car-will-not-start.html

Honda car will not start intermittently?

http://technoanswers.blogspot.in/2012/02/honda-car-will-not-start-intermittently.html

Toyota car will not start?

http://technoanswers.blogspot.in/2012/02/toyota-car-will-not-start.html

1994 ford E150 Timing problem?

http://technoanswers.blogspot.in/2012/02/1994-ford-e150-timing-problem.html

Cruise control stop working on 1994 Ford ranger?

http://technoanswers.blogspot.in/2012/02/cruise-control-stop-working-on-1994.html

Ford explorer 4.0 will not idle when cold?

http://technoanswers.blogspot.in/2012/02/ford-explorer-40-will-not-idle-when.html

Water flowing back into overflow tank?

http://repairhelpcenter.blogspot.in/2012/02/water-flowing-back-into-overflow-tank.html

Jeep starts with key in on position?

http://technoanswers.blogspot.in/2012/02/jeep-starts-with-key-in-on-position.html

Jeep Backfires?

http://technoanswers.blogspot.in/2012/02/jeep-backfires.html

Nissan Pathfinder stalls and bucks on Acceleration?

Nissan Pathfinder Backfires?

http://technoanswers.blogspot.in/2012/02/nissan-pathfinder-backfires.html


No comments:

Post a Comment