Sunday, March 11, 2012

Ford Taurus 5 & 7 Series Heater core replace?

Heater core replace procedure is similar for for Ford and mercury model.


5 & 7 Series



2001-03 5 Series And 2001 7 Series
  1. Disconnect the negative battery cable.
  2. Drain the cooling system into a clean container for reuse.
  3. Remove or disconnect the following:

    Screws retaining the center console
    Ashtray assembly
    Glove box door assembly
    Right side heater case cover screws and remove the cover
    Front vent drive motor
    Plug from the inside temperature sensor
    Heater core cover retaining screws
    Cover clips and straps
    Cover and gasket
    Coolant hoses from the heater core
    Heater pipe-to-heater core retaining bolts
    Heater pipes
    Heater core retaining bolts
    Heater core by tilting it to the side
  4. Click image to see an enlarged view
    Fig. View of the heater/blower housing assembly
    Click image to see an enlarged view
    Fig. Removing the heater core cover
    Click image to see an enlarged view
    Fig. Removing the heater water pipes
    Click image to see an enlarged view
    Fig. Remove the heater by pulling to the right
To install:
  1. Install or connect the following:

    Heater core in the heater case
    Heater core retaining bolts
    Heater pipes to the heater core. Tighten the M6 bolts to 72-84 inch lbs. (8.1-9.5 Nm) and the M8 bolts to 16-17 ft. lbs. (21.7-23.0 Nm). Connect the heater hoses. Always use new O-rings on the heater pipes.
    Heater case cover and retaining clips
    Cover retaining screws. Make sure the cover gasket is properly positioned.
    Front vent drive motor
    Right heater case cover
    Inside temperature sensor
    Glove box door assembly
    Center console and the ashtray
  2. Refill the cooling system and connect the negative battery cable.
  3. Operate the engine to normal operating temperatures; then, check the climate control operation and check for leaks.
      1. This will help.Thanks.
        FOR MORE HELP GO TO: ---

        Car repair guide?

        http://technoanswers.blogspot.in/2012/03/car-repair-guide.html


      No comments:

      Post a Comment