Monday, March 12, 2012

PCM Pin Layout details and Diagram for Ford Details?

PCM connector pin details.
Pin out details for engine module on ford.

Connector Pin Identification details are as follows :---

This details will explain you what Pin number in Pcm is controlling what part of the car.So as per that you can test the exact part.


1998-2000 Windstar 3.0L V6 VIN U (A/T) 104 Pin Connector
PCM Pin #Wire ColorCircuit Description (104 Pin)Value at Hot Idle
1PK/ORShift Solenoid 2/B Control1v, 55 mph: 12v
2 ('98-'99)PK/LGMIL (lamp) ControlMIL On: 1v, Off: 12v
3OR/BKDigital TR1 SensorIn 'P': 0v, 55 mph: 11v
4-5---Not Used---
6DB/YLOutput Shaft Speed Sensor0 Hz, 55 mph: 2 KHz
7-12---Not Used---
13VTFlash EEPROM0.1v
14---Not Used---
15PK/LBData Bus (-)Digital Signals
16TN/ORData Bus (+)Digital Signals
17 ('98-'99)LG/PKHigh Speed Fan ControlFan On: 1v, Off: 12v
18-20---Not Used---
21BK/PKCKP (+) Sensor518-540 Hz
22GY/YLCKP (-) Sensor518-540 Hz
23---Not Used---
24BK/WTPower Ground 
25BKCase Ground 
26DB/LGCoil 1 Driver (Dwell)5°, at 55 mph: 8°
27OR/YLShift Solenoid 1/A Control12v, 55 mph: 1v
28DBLow Speed Fan ControlFan On: 1v, Off: 12v
29-34---Not Used---
35RD/LGHO2S-12 (B1 S2) Signal0.1-1.1v
36TN/LBMAF Sensor Return 
37OR/BKTransmission Fluid Temperature Sensor2.10-2.40v
38LG/RDEngine Coolant Temperature Sensor0.5-0.6v
39GYIntake Air Temperature Sensor1.5-2.5v
40DG/YLFuel Pump MonitorOn: 12v, Off: 0v
41BK/YLA/C High Pressure SwitchA/C On: 12v, off: 0v
42---Not Used---
43OR/LGFuel Flow Output SignalDigital Signals
44-45---Not Used---
46LG/PKHigh Speed Fan ControlFan On: 1v, Off: 12v
47BR/PKVR Solenoid Control0%, at 55 mph: 45%
48---Not Used---
49LB/BKDigital TR2 SensorIn 'P': 0v, 55 mph: 11v
50WT/BKDigital TR4 SensorIn 'P': 0v, 55 mph: 11v
51BK/WTPower Ground 
52RD/LBCoil 2 Driver (Dwell)5°, at 55 mph: 8°
53PK/BKShift Solenoid 3/C Control12v, 55 mph: 1v
54RD/LBTCC Solenoid Control0%, at 55 mph: 95%
55YKeep Alive Power12-14v
56LG/BKEVAP Purge Solenoid0-10 Hz (0-100%)
57-59---Not Used---
60GY/LBHO2S-11 (B1 S1) Signal0.1-1.1v
61PK/LGHO2S-22 (B2 S2) Signal0.1-1.1v
62RD/PKFuel Tank Pressure Sensor2.6v at 0" Hg (cap off)
63---Not Used---
64LB/YLTransmission Range SensorIn 'P': 0v, in O/D: 1.7v
1998-2000 Windstar 3.0L V6 VIN U (A/T) 104 Pin Connector
PCM Pin #Wire ColorCircuit Description (104 Pin)Value at Hot Idle
65BR/LGEGR DPFE Sensor Signal0.20-1.30v
66---Not Used---
67PKWTEVAP CV Solenoid0-10 Hz (0-100%)
68---Not Used---
69PK/YLA/C WOT Relay ControlOn: 1v, Off: 12v
70---Not Used---
71RDVehicle Power12-14v
72---Not Used---
73TN/BKInjector 5 Control5.0-5.2 ms
74BR/YLInjector 3 Control5.0-5.2 ms
75TNInjector 1 Control5.0-5.2 ms
76BK/WTPower Ground 
77BK/WTPower Ground 
78PKWTCoil 3 Driver (Dwell)5°, at 55 mph: 8°
79---Not Used---
80LB/ORFuel Pump ControlOn: 1v, Off: 12v
81WT/YLEPC Solenoid Control9.9v (15 psi)
82---Not Used---
83WT/LBIAC Solenoid Control10.7v (33%)
84GY/BKTurbine Shaft Speed Sensor120 Hz, 30 mph: 300 Hz
85DB/ORCamshaft Position Sensor6 Hz, 55 mph: 15-20 Hz
86TN/LGA/C Pressure Switch SignalSwitch On: 12v (Open)
87RD/BKHO2S-21 (B2 S1) Signal0.1-1.1v
88LB/RDMAF Sensor Signal0.8v, 55 mph: 1.9v
89GY/WTTP Sensor Signal0.9v, 55 mph: 1.2v
90BR/WTReference Voltage4.9-5.1v
91GY/RDAnalog Signal Return 
92---Not Used---
93RD/WTHO2S-11 (B1 S1) Heater1v, Off: 12v
94YL/LBHO2S-21 (B2 S1) Heater1v, Off: 12v
95WT/BKHO2S-12 (B1 S2) Heater1v, Off: 12v
96TN/YLHO2S-22 (B2 S2) Heater1v, Off: 12v
97RDVehicle Power12-14v
98---Not Used---
99LG/ORInjector 6 Control5.0-5.2 ms
100BR/LBInjector 4 Control5.0-5.2 ms
101WTInjector 2 Control5.0-5.2 ms
102---Not Used---
103BK/WTPower Ground 
104---Not Used---


2000 Windstar 3.8L V6 VIN 4 (A/T) 104 Pin Connector
PCM Pin #Wire ColorCircuit Description (104 Pin)Value at Hot Idle
1VT/ORShift Solenoid 2 Control1v, 55 mph: 12v
2---Not Used---
3OR/BKDigital TR1 SensorIn 'P': 0v, 55 mph: 10.7v
4-5---Not Used---
6DG/WTTurbine Shaft Speed Sensor43 Hz, 55 mph: 108 Hz
7---Not Used---
8OR/WTIMRC Monitor Signal5v, 55 mph: 5v
9-12---Not Used---
13VTFlash EEPROM0.1v
14---Not Used---
15PK/LBSCP Data Bus (-) 
16TN/ORSCP Data Bus (+)Digital Signals
17GN/ORPATSIN Signal12v
18WT/LGPATSOUT Signal12v
19---Not Used---
20VTGenerator Field Signal130 Hz (37%)
21BK/PKCKP (-) Sensor390-450 Hz
22GY/YLCKP (+) Sensor390-450 Hz
23---Not Used---
24BK/WTPower Ground 
25---Not Used---
26DB/LGCoil 1 Driver (Dwell)5°, at 55 mph: 8°
27OR/YLShift Solenoid 'A' Control12v, 55 mph: 1v
28DBLow Speed Fan ControlFan On: 1v, Off: 12v
29---Not Used---
30DB/LGPassive Antitheft Indicator ControlIndicator Off: 12v, On: 1v
31YL/LGPower Steering Pressure SwitchStraight: 0v, Turned: 12v
32-34---Not Used---
35RD/LGHO2S-12 (B1 S2) Signal0.1-1.1v
36TN/LBMAF Sensor Return 
37OR/BKTransmission Fluid Temperature Sensor2.10-2.40v
38LG/RDEngine Coolant Temperature Sensor0.5-0.6v
39GYIntake Air Temperature Sensor1.5-2.5v
40DG/YLFuel Pump MonitorOff: 0v, On: 12v
41BK/YLA/C Pressure Switch SignalA/C On: 12v, off: 0v
42BRIMRC Solenoid Control12v, 55 mph: 12v
43---Not Used---
44LG/YLPATSTRT0v
45RD/PKGenerator Communication0-130 Hz
46LG/VTHigh Speed Fan Relay ControlRelay Off: 12v, On: 1v
47BR/PKEGR VR Solenoid Control0%, at 55 mph: 45%
48---Not Used---
49LG/BKDigital TR2 SensorIn 'P': 0v, 55 mph: 10.7v
50WT/BKDigital TR4 SensorIn 'P': 0v, 55 mph: 10.7v
51BK/WTPower Ground 
52RD/LBCoil 2 Driver (Dwell)5°, at 55 mph: 8°
53PK/BKShift Solenoid 'C' Control12v, 55 mph: 1v
54RD/LBTCC Solenoid Control12v (0% duty cycle)
55RDDirect Battery12-14v
56LG/BKEVAP Canister Purge Solenoid0-10 Hz (0-100%)
57-59---Not Used---
60GY/LBHO2S-11 (B1 S1) Signal0.1-1.1v
61PK/LGHO2S-22 (B2 S2) Signal0.1-1.1v
62RD/PKFuel Tank Pressure Sensor2.6v at 0" Hg (cap off)
63---Not Used---
64LB/YLDigital TR3 Sensor SignalIn 'P': 0v, in O/D: 1.7v
2000 Windstar 3.8L V6 VIN 4 (A/T) 104 Pin Connector
PCM Pin #Wire ColorCircuit Description (104 Pin)Value at Hot Idle
65BR/LGEGR DPFE Sensor Signal0.20-1.30v
66---Not Used---
67VT/WTEVAP CV Solenoid0-10 Hz (0-100%)
68---Not Used---
69PK/YLA/C WOT Relay ControlOn: 1v, Off: 12v
70---Not Used---
71RDVehicle Power (Start-Run)12-14v
72---Not Used---
73TN/BKInjector 5 Control3.0-4.0 ms
74BR/YLInjector 3 Control3.0-4.0 ms
75TNInjector 1 Control3.0-4.0 ms
76BK/WTPower Ground 
77---Not Used---
78PKWTCoil 3 Driver (Dwell)5°, at 55 mph: 8°
79---Not Used---
80LB/ORFuel Pump ControlOn: 1v, Off: 12v
81WT/YLEPC Solenoid Control9.2v (15 psi)
82---Not Used---
83WT/LBIAC Solenoid Control10.7v (33%)
84DB/YLOutput Shaft Speed Sensor0 Hz, 55 mph: 475 Hz
85DB/ORCamshaft Position Sensor6 Hz, 55 mph: 13-15 Hz
86TN/LGA/C Pressure Switch Signal1v (54 psi)
87RD/BKHO2S-21 (B2 S1) Signal0.1-1.1v
88LB/RDMAF Sensor Signal0.8v, 55 mph: 1.8v
89GY/WTTP Sensor Signal0.53-1.27v
90BR/WTReference Voltage4.9-5.1v
91GY/RDSensor Ground 
92---Not Used---
93RD/WTHO2S-11 (B1 S1) Heater1v, Off: 12v
94YL/LBHO2S-21 (B2 S1) Heater1v, Off: 12v
95WT/BKHO2S-12 (B1 S2) Heater1v, Off: 12v
96TN/YLHO2S-22 (B2 S2) Heater1v, Off: 12v
97-98---Not Used---
99LG/ORInjector 6 Control3.0-4.0 ms
100BR/LBInjector 4 Control3.0-4.0 ms
101WTInjector 2 Control3.0-4.0 ms
102---Not Used---
103BK/WTPower Ground 
104---Not Used---
2001-03 Windstar 3.8L V6 VIN 4 (A/T) 104 Pin Connector
PCM Pin #Wire ColorCircuit Description (104 Pin)Value at Hot Idle
1VT/ORShift Solenoid 2 Control1v, 55 mph: 12v
2---Not Used---
3OR/BKDigital TR1 SensorIn 'P': 0v, 55 mph: 10.7v
4-5---Not Used---
6DG/WTTurbine Shaft Speed Sensor43 Hz, 55 mph: 108 Hz
7---Not Used---
8OR/WTIMRC Monitor Signal5v, 55 mph: 5v
9-12---Not Used---
13VTFlash EEPROM0.1v
14---Not Used---
15PK/LBSCP Data Bus (-) 
16TN/ORSCP Data Bus (+)Digital Signals
17GY/ORPATSIN Signal12v
18WT/LGPATSOUT Signal12v
19---Not Used---
20VTGenerator Field Signal130 Hz (37%)
21BK/PKCKP (-) Sensor390-450 Hz
22GY/YLCKP (+) Sensor390-450 Hz
23---Not Used---
24BK/WTPower Ground 
25---Not Used---
26DB/LGCoil 1 Driver (Dwell)5°, at 55 mph: 8°
27OR/YLShift Solenoid 'A' Control12v, 55 mph: 1v
28DBLow Speed Fan ControlFan On: 1v, Off: 12v
29---Not Used---
30DB/LGPassive Antitheft Indicator ControlIndicator Off: 12v, On: 1v
31YL/LGPower Steering Pressure SwitchStraight: 0v, Turned: 12v
32-34---Not Used---
35RD/LGHO2S-12 (B1 S2) Signal0.1-1.1v
36TN/LBMAF Sensor Return 
37OR/BKTransmission Fluid Temperature Sensor2.10-2.40v
38LG/RDEngine Coolant Temperature Sensor0.5-0.6v
39GYIntake Air Temperature Sensor1.5-2.5v
40DG/YLFuel Pump MonitorOff: 0v, On: 12v
41BK/YLA/C Pressure Switch SignalA/C On: 12v, off: 0v
42BRIMRC Solenoid Control12v, 55 mph: 12v
43---Not Used---
44LG/YLPATSTRT0v
45RD/PKGenerator Communication0-130 Hz
46LG/VTHigh Speed Fan Relay ControlRelay Off: 12v, On: 1v
47BR/PKEGR VR Solenoid Control0%, at 55 mph: 45%
48---Not Used---
49LG/BKDigital TR2 SensorIn 'P': 0v, 55 mph: 10.7v
50WT/BKDigital TR4 SensorIn 'P': 0v, 55 mph: 10.7v
51BK/WTPower Ground 
52RD/LBCoil 2 Driver (Dwell)5°, at 55 mph: 8°
53PK/BKShift Solenoid 'C' Control12v, 55 mph: 1v
54RD/LBTCC Solenoid Control12v (0% duty cycle)
55RDDirect Battery12-14v
56LG/BKEVAP Canister Purge Solenoid0-10 Hz (0-100%)
57-59---Not Used---
60GY/LBHO2S-11 (B1 S1) Signal0.1-1.1v
61VT/LGHO2S-22 (B2 S2) Signal0.1-1.1v
62RD/PKFuel Tank Pressure Sensor2.6v at 0" Hg (cap off)
63---Not Used---
64LB/YLDigital TR3 Sensor SignalIn 'P': 0v, in O/D: 1.7v
2001-03 Windstar 3.8L V6 VIN 4 (A/T) 104 Pin Connector
PCM Pin #Wire ColorCircuit Description (104 Pin)Value at Hot Idle
65BR/LGEGR DPFE Sensor Signal0.95-1.05v
66---Not Used---
67VT/WTEVAP CV Solenoid0-10 Hz (0-100%)
68---Not Used---
69PK/YLA/C WOT Relay ControlOn: 1v, Off: 12v
70---Not Used---
71RDVehicle Power (Start-Run)12-14v
72---Not Used---
73TN/BKInjector 5 Control3.0-4.0 ms
74BR/YLInjector 3 Control3.0-4.0 ms
75TNInjector 1 Control3.0-4.0 ms
76BK/WTPower Ground 
77---Not Used---
78PKWTCoil 3 Driver (Dwell)5°, at 55 mph: 8°
79---Not Used---
80LB/ORFuel Pump Relay ControlOff: 12v, On: 1v
81WT/YLEPC Solenoid Control9.2v (15 psi)
82---Not Used---
83WT/LBIAC Solenoid Control10.7v (33%)
84DB/YLOutput Shaft Speed Sensor0 Hz, 55 mph: 475 Hz
85DB/ORCamshaft Position Sensor6 Hz, 55 mph: 13-15 Hz
86TN/LGA/C Pressure Switch Signal1v (54 psi)
87RD/BKHO2S-21 (B2 S1) Signal0.1-1.1v
88LB/RDMAF Sensor Signal0.8v, 55 mph: 1.8v
89GY/WTTP Sensor Signal0.53-1.27v
90BR/WTReference Voltage4.9-5.1v
91GY/RDSensor Ground 
92---Not Used---
93RD/WTHO2S-11 (B1 S1) Heater1v, Off: 12v
94YL/LBHO2S-21 (B2 S1) Heater1v, Off: 12v
95WT/BKHO2S-12 (B1 S2) Heater1v, Off: 12v
96TN/YLHO2S-22 (B2 S2) Heater1v, Off: 12v
97-98---Not Used---
99LG/ORInjector 6 Control3.0-4.0 ms
100BR/LBInjector 4 Control3.0-4.0 ms
101WTInjector 2 Control3.0-4.0 ms
102---Not Used---
103BK/WTPower Ground 
104---Not Used---
This section can be used to look up the location of a particular pin, a Wire Color or a "known good" value of a PCM circuit. To locate the PCM information for a particular vehicle, find the model, correct engine size (with VIN Code) and finally the year of the vehicle.
For example, to look up the PCM terminals for a 1999 Mustang 4.6L VIN W, and find the text string shown below:
In this example, the Fuel Level Indicator circuit is connected to Pin 12 of the 104 Pin Connector by a Yellow/White wire. The value at Hot Idle shown here is the normal value for the fuel level with the tank 1/2 full.
The "All" that appears in the Title of the table indicates the information is for both automatic and manual transmission vehicle applications.
Pin Connector Graphic 


image

Standard Colors and Abbreviations
AbbreviationColorAbbreviationColorAbbreviationColor
BKBlackGYGrayPKPurple
BLBlueGNGreenRDRed
BRBrownLGLT GreenTNTan
DBDark BlueOROrangeWTWhite
DGDK GreenPKPinkYLYellow


This details will help.
Thanks.

FOR MORE HELP GO TO: ---

Car repair guide?

http://technoanswers.blogspot.in/2012/03/car-repair-guide.html


No comments:

Post a Comment