Friday, March 2, 2012

Volkswagen syncro transporter transfer box removal?

The procedure to replace transfer case box on VW transporter.

To remove the transfer box you will need to remove the offside drive shaft and release the prop shaft and take the rubber mount out. Once that is out,then remove the mount on the lower section of the box.

Unscrew speedometer drive shaft cable or remove sender connector and speedometer sender.
‒ → Drive output shaft drive flange -A- out from locking device in differential using a synthetic head hammer.
‒ The output shaft drive flange can also be pulled out with bolt M 10, .
‒ Remove gearbox carrier -B- from engine and bevel box -C-.

See the diagram shown below :--------
graphic

→ Remove the four bevel box/gearbox connecting bolts (arrows 1, two further bolts hidden).
  • ‒ Press bevel box off gearbox (direction of arrow).

  • ‒ Guide bevel box out between subframe and sump, when doing this ensure that the drive flange/output shaft cannot fall out.


  • See this another diagram for more help :--------
    graphic


    This will help.
    Thanks.
    See below latest solved car problems :------

    Car suddenly died and won’t start?

    http://technoanswers.blogspot.in/2012/02/car-suddenly-died-and-wont-start.html

    Car is starting but not turning over?

    http://technoanswers.blogspot.in/2012/02/car-is-starting-but-not-turning-over.html

    Engine cranks but will not start?

    http://technoanswers.blogspot.in/2012/02/engine-cranks-but-will-not-start.html

    Exclamation indicator light on ford freestar dash?

    http://technoanswers.blogspot.in/2012/02/exclamation-indicator-light-on-ford.html

    2004 ford freestar van idles rough?

    How to remove Intake Manifold Tuning Valve?

    http://technoanswers.blogspot.com/2012/01/how-to-remove-intake-manifold-tuning.html

    Trunk release Problem on Toyota Camry?

    http://schematicsdiagram.blogspot.in/2012/02/trunk-release-problem-on-toyota-camry.html

    CMFI details for GMC vehicles?

    http://technoanswers.blogspot.com/2012/01/cmfi-details-for-gmc-vehicles.html

    Mazda MPV cranks but will not start?

    http://technoanswers.blogspot.com/2012/01/mazda-mpv-cranks-but-will-not-start.html

    MAZDA MPV WILL CRANK BUT NOT TURN OVER TO START?

    http://technoanswers.blogspot.com/2012/01/mazda-mpv-will-crank-but-not-turn-over.html

    Freightliner fl112 fuse box diagram?

    http://technoanswers.blogspot.com/2012/01/freightliner-fl112-fuse-box-diagram.html

    Car will not turn the ignition to start?

    http://technoanswers.blogspot.com/2012/01/car-will-not-turn-ignition-to-start.html

    Car only starts when gas pedal is pressed?

    http://technoanswers.blogspot.com/2012/01/car-only-starts-when-gas-pedal-is.html

    How to compare pattern of left bank and right bank sensors?

    http://schematicsdiagram.blogspot.in/2012/02/how-to-compare-pattern-of-left-bank-and.html

    Where is secondary air pump solenoids located?

    http://repairhelpcenter.blogspot.in/2012/03/where-is-secondary-air-pump-solenoids.html

    Check power train warning light on?

    http://howtobyme.blogspot.in/2012/02/check-powertrain-warning-light-on.html

    Check power-train message with orange engine light came on?

    Check Powertrain message and Safety Mode Reduced Performance on Holden VZ Commodore?

    http://howtobyme.blogspot.in/2012/02/check-powertrain-message-and-safety.html

    Hyundai coupe f2 hazard fault?

    http://schematicsdiagram.blogspot.com/2012/01/hyundai-coupe-f2-hazard-fault.html

    Where is the pcv valve located on 2007 Duratec ford focus xr5?

    http://repairhelpcenter.blogspot.in/2012/02/where-is-pcv-valve-located-on-2007.html

    Bottoms Out while driving?

    http://schematicsdiagram.blogspot.in/2012/02/bottoms-out-while-driving.html

    Gas door hinges broken on Toyota?

    http://technoanswers.blogspot.in/2012/02/gas-door-hinges-broken-on-toyota.html

    From where to buy new flow valve for Citroen 16 BX?

    http://schematicsdiagram.blogspot.in/2012/02/from-where-to-buy-new-flow-valve-for.html

    Where is the throttle position sensor located on the 1999 Cadillac DeVille?

    http://schematicsdiagram.blogspot.in/2012/02/where-is-throttle-position-sensor.html

          

    Where is the bulb located in glove box?

    http://repairhelpcenter.blogspot.com/2012/01/where-is-bulb-located-in-glove-box.html



    No comments:

    Post a Comment